Appendix C  Defiance DPM Noise and Vibration Measurement Report  Detroit Transportation Corporation: 

 Appendix C Defiance DPM Noise and Vibration Measurement Report Detroit Transportation Corporation: Noise Abatement and Ride Quality Study Detroit Transportation Corporation
Detroit People Mover Noise and Vibration Measurement
Defiance Testing & Engineering
Report No. 106145-000
Prepared for:
Prepared by:
Detroit Transportation Corporation
Hong Yin
1420 Washington Blvd
Detroit, Mi 48226
Attn: Cornelius Henry
Phone: 313 224 2160 Ext. 5234
chenry@the peoplemover.com
___________________
Hong Yin
Senior Project Engineer
(248) 458-5900 x 219
[email protected]
September 7, 2011
PUT OUR PRODUCT DEVELOPMENT TO THE TEST
1628 Northwood Troy, MI 48084 Phone 248·458·5900 Fax 248·458·5901
5859 Executive Drive Westland, MI 48185 Phone 734·326·7090 Fax 734·326·0367
DEFIANCE
TABLE OF CONTENTS
Page
1.0
Objective..............................................................................................................….1
2.0
Instrumentation and Test Procedures..........................................................……1
Appendix A: Instrumentation Setup Photographs……………………….…..A1-A9
Appendix B: Statistic Results……………………………………………………B1-B4
Appendix C: Result Plots………………………………………………………C1-C16
Appendix D: Equipment List ....................................................................................….D1
106145-000 Report
DEFIANCE
Detroit Transportation Corporation
Detroit People Mover Noise and Vibration Measurement
Defiance Testing & Engineering
Report No. 106145-000
1.0
OBJECTIVE
The objective of this project was to instrument a people mover car and perform
noise and vibration measurement.
2.0
INSTRUMENTATION and TEST PROCEDURES
Defiance instrumented a people mover car and performed noise and vibration
measurement from August 27 to 28, 2011 at Detroit Transportation Corporation’s
facility in Detroit, MI. Defiance instrumented a people mover car with total of
32 channels as per Table No.1 Instrumentation Channel List. The front truck of the
test car was a new one and the rear truck was an old one. Appendix A shows
instrumentation photographs. LMS SCADAS Mobile system with Test.Lab
software was utilized to collect and process noise and vibration data. Data
acquisition sample rates were set to 52 KHz for microphones and 4,096Hz for
accelerations and loads.
Data were collected as two laps of clockwise (Run1 and Run3) and two laps of
counter-clockwise (Run2 and Run4). The front end of the test car was
connected to another car. Test car was in the front during counter-clockwise test
runs. All the speakers and fans in the car were turn off during the test. Car was
stopped at every station with the doors opened and closed.
3.0
RESULT SUMMARY
Appendix B lists statistic results for the data of the four test runs.
Appendix C Result Plots shows the following plots and results:
• Link load time plots with maximum and minimum loads.
• Microphone sound pressure level time plots with RMS sound pressure
levels.
• Microphone loudness time plots with RMS loudness.
• Microphone 1/3rd Octave frequency plots.
• Wheel Mount Acceleration Time Plots with Maximum and Minimum
Accelerations.
Equipment items used for this test are listed in Appendix D: Equipment List.
Page 1 of 2
106145-000 Report
DEFIANCE
Table No. 1 Instrumentation Channel List
People Mover Instrumentation Channel List
Channel No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
Channel Description
Front Car Microphone
Rear Car Microphone
Front Truck LF Wheel Mnt Accel X
Front Truck LF Wheel Mnt Accel Y
Front Truck LF Wheel Mnt Accel Z
Front Truck RR Wheel Mnt Accel X
Front Truck RR Wheel Mnt Accel Y
Front Truck RR Wheel Mnt Accel Z
Front Truck Left Bolster Car Side Accel Z
Front Truck Left Bolster Truck Side Accel Z
Front Truck Right Bolster Car Side Accel Z
Front Truck Right Bolster Truck Side Accel Z
Front Truck Pivot Car Side Accel X
Front Truck Pivot Car Side Accel Y
Front Truck Pivot Car Side Accel Z
Rear Truck LF Wheel Mnt Accel X
Rear Truck LF Wheel Mnt Accel Y
Rear Truck LF Wheel Mnt Accel Z
Rear Truck RR Wheel Mnt Accel X
Rear Truck RR Wheel Mnt Accel Y
Rear Truck RR Wheel Mnt Accel Z
Rear Truck Left Bolster Car Side Accel Z
Rear Truck Left Bolster Truck Side Accel Z
Rear Truck Right Bolster Car Side Accel Z
Rear Truck Right Bolster Truck Side Accel Z
Rear Truck Pivot Car Side Accel X
Rear Truck Pivot Car Side Accel Y
Rear Truck Pivot Car Side Accel Z
Front Truck Long Link Load
Front Truck Short Link Load
Rear Truck Long Link Load
Rear Truck Short Link Load
Page 2 of 2
EU
Pa
Pa
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
lbs
lbs
lbs
lbs
Positive Direction
NA
NA
FWD
Right
Up
FWD
Right
Up
Up
Up
Up
Up
FWD
Right
Up
FWD
Right
Up
FWD
Right
Up
Up
Up
Up
Up
FWD
Right
Up
Tension
Tension
Tension
Tension
106145-000 Report
DEFIANCE
Appendix A
Instrumentation Setup Photographs
106145-000 Report
DEFIANCE
Page A1 of A9
106145-000 Report
105791-0
DEFIANCE
Page A2 of A9
106145-000 Report
105791-0
DEFIANCE
Page A3 of A9
106145-000 Report
105791-0
DEFIANCE
Page A4 of A9
106145-000 Report
105791-0
DEFIANCE
Page A5 of A9
106145-000 Report
105791-0
DEFIANCE
Page A6 of A9
106145-000 Report
105791-0
DEFIANCE
Page A7 of A9
106145-000 Report
105791-0
DEFIANCE
Page A8 of A9
106145-000 Report
105791-0
DEFIANCE
Page A9 of A9
106145-000 Report
105791-0
DEFIANCE
Appendix B
Statistic Results
106145-000 Report
DEFIANCE
Statistics for Run1 Data
Channels
5:Front Truck LF Wheel Mnt Accel X:+X
6:Front Truck LF Wheel Mnt Accel Y:+Y
7:Front Truck LF Wheel Mnt Accel Z:+Z
8:Front Truck RR Wheel Mnt Accel X:+X
9:Front Truck RR Wheel Mnt Accel Y:+Y
10:Front Truck RR Wheel Mnt Accel Z:+Z
11:Front Truck Left Bolser Car Side Accel Z:+Z
12:Front Truck Left Bolster Truck Side Accel Z:+Z
13:Front Truck Right Bolser Car Side Accel Z:+Z
14:Front Truck Right Bolster Truck Side Accel Z:+Z
15:Front Truck Pivot Car Side Accel X:+X
16:Front Truck Pivot Car Side Accel Y:+Y
17:Front Truck Pivot Car Side Accel Z:+Z
18:Rear Truck LF Wheel Mnt Accel X:+X
19:Rear Truck LF Wheel Mnt Accel Y:+Y
20:Rear Truck LF Wheel Mnt Accel Z:+Z
21:Rear Truck RR Wheel Mnt Accel X:+X
22:Rear Truck RR Wheel Mnt Accel Y:+Y
23:Rear Truck RR Wheel Mnt Accel Z:+Z
24:Rear Truck Left Bolser Car Side Accel Z:+Z
25:Rear Truck Left Bolster Truck Side Accel Z:+Z
26:Rear Truck Right Bolster Car Side Accel Z:+Z
27:Rear Truck Right Bolster Truck Side Accel Z:+Z
28:Rear Truck Pivot Car Side Accel X:+X
29:Rear Truck Pivot Car Side Accel Y:+Y
30:Rear Truck Pivot Car Side Accel Z:+Z
31:Front Truck Long Link Load
32:Front Truck Short Link Load
33:Rear Truck Long Link Load
34:Rear Truck Short Link Load
RMS
1.09
1.87
0.89
0.86
1.68
0.85
0.06
0.42
0.07
0.41
0.24
0.33
0.09
0.92
1.71
0.71
1
1.72
0.84
0.06
0.41
0.06
0.41
0.21
0.48
0.09
88.59
1021.76
735.13
500.76
Max
32.18
79.25
41.57
26.6
68.19
34.04
1.49
8.74
1.36
13.79
5.28
9.1
2.52
43.8
77.07
35.7
35.75
79.45
45.68
2.17
11.24
3.79
15.4
5.86
16.19
2.26
508.94
4479.38
1232.91
3631.59
Page. B1 of B4
Min
-33.46
-75.04
-31.12
-39.5
-51.09
-29.17
-1.43
-9.93
-1.54
-9.78
-6.55
-6.9
-2.21
-44.94
-73.22
-30.08
-33.67
-76.93
-32.34
-1.72
-8.98
-1.51
-11.94
-7.08
-16.42
-1.86
-508.94
-2974.81
89.84
-3284.53
Range
65.64
154.29
72.69
66.1
119.28
63.21
2.92
18.67
2.9
23.57
11.83
16
4.73
88.74
150.29
65.78
69.42
156.38
78.02
3.89
20.22
5.3
27.34
12.94
32.61
4.12
1017.88
7454.19
1143.07
6916.12
Average
-2.42E-07
7.51E-07
-1.64E-06
9.36E-07
-1.81E-06
5.54E-07
-2.32E-06
1.81E-06
1.74E-07
1.40E-06
5.04E-07
2.96E-06
-2.78E-06
1.55E-07
2.86E-06
-2.38E-07
8.97E-07
-1.16E-06
-4.13E-06
-6.38E-06
1.92E-06
5.01E-06
7.57E-06
1.37E-06
-1.67E-07
-1.65E-06
65.74
883.71
712.09
357.61
EU
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
lbf
lbf
lbf
lbf
106145-000 Report
DEFIANCE
Statistics for Run2 Data
Channel
5:Front Truck LF Wheel Mnt Accel X:+X
6:Front Truck LF Wheel Mnt Accel Y:+Y
7:Front Truck LF Wheel Mnt Accel Z:+Z
8:Front Truck RR Wheel Mnt Accel X:+X
9:Front Truck RR Wheel Mnt Accel Y:+Y
10:Front Truck RR Wheel Mnt Accel Z:+Z
11:Front Truck Left Bolser Car Side Accel Z:+Z
12:Front Truck Left Bolster Truck Side Accel Z:+Z
13:Front Truck Right Bolser Car Side Accel Z:+Z
14:Front Truck Right Bolster Truck Side Accel Z:+Z
15:Front Truck Pivot Car Side Accel X:+X
16:Front Truck Pivot Car Side Accel Y:+Y
17:Front Truck Pivot Car Side Accel Z:+Z
18:Rear Truck LF Wheel Mnt Accel X:+X
19:Rear Truck LF Wheel Mnt Accel Y:+Y
20:Rear Truck LF Wheel Mnt Accel Z:+Z
21:Rear Truck RR Wheel Mnt Accel X:+X
22:Rear Truck RR Wheel Mnt Accel Y:+Y
23:Rear Truck RR Wheel Mnt Accel Z:+Z
24:Rear Truck Left Bolser Car Side Accel Z:+Z
25:Rear Truck Left Bolster Truck Side Accel Z:+Z
26:Rear Truck Right Bolster Car Side Accel Z:+Z
27:Rear Truck Right Bolster Truck Side Accel Z:+Z
28:Rear Truck Pivot Car Side Accel X:+X
29:Rear Truck Pivot Car Side Accel Y:+Y
30:Rear Truck Pivot Car Side Accel Z:+Z
31:Front Truck Long Link Load
32:Front Truck Short Link Load
33:Rear Truck Long Link Load
34:Rear Truck Short Link Load
RMS
1.11
2.2
0.96
0.92
1.74
0.86
0.06
0.43
0.07
0.41
0.24
0.34
0.09
0.93
1.71
0.7
0.98
1.72
0.85
0.06
0.4
0.06
0.41
0.22
0.49
0.08
145.62
581.35
130.81
573.15
Page. B2 of B4
Max
70.1
102.65
47.77
30
65.78
30.14
1.4
7.59
1.27
12.23
7.03
7.12
2.04
41.13
96.47
36.92
38.09
76.27
30.49
1.51
10.6
3.02
18.67
7.29
14.98
2.59
553.92
3817.44
829.23
3792.29
Min
-55.72
-67.88
-31.9
-30.94
-50.72
-25.36
-1.38
-8.05
-1.25
-9.64
-5.87
-7.45
-2.1
-34.72
-73.49
-29.36
-36.81
-75.8
-27.63
-1.64
-10.84
-1.5
-13.6
-6.68
-14.49
-1.98
-553.92
-3817.44
-450.69
-3790.12
Range
125.82
170.53
79.67
60.94
116.5
55.5
2.78
15.64
2.52
21.87
12.9
14.57
4.14
75.85
169.96
66.28
74.9
152.07
58.12
3.15
21.44
4.52
32.27
13.97
29.47
4.57
1107.84
7634.88
1279.92
7582.41
Average
-3.51E-06
-2.24E-05
-2.64E-07
3.48E-07
-6.25E-07
-5.60E-08
-5.43E-07
2.32E-06
3.64E-07
-9.74E-07
-4.13E-07
1.05E-06
-6.15E-07
-1.25E-06
1.70E-06
-2.40E-06
-1.38E-07
-1.03E-06
-3.19E-06
-1.75E-06
7.28E-07
-8.38E-07
4.90E-06
1.28E-06
3.58E-07
-6.21E-07
117.11
434.24
100.64
380.42
EU
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
lbf
lbf
lbf
lbf
106145-000 Report
DEFIANCE
Statistics for Run3 Data
Channels
5:Front Truck LF Wheel Mnt Accel X:+X
6:Front Truck LF Wheel Mnt Accel Y:+Y
7:Front Truck LF Wheel Mnt Accel Z:+Z
8:Front Truck RR Wheel Mnt Accel X:+X
9:Front Truck RR Wheel Mnt Accel Y:+Y
10:Front Truck RR Wheel Mnt Accel Z:+Z
11:Front Truck Left Bolser Car Side Accel Z:+Z
12:Front Truck Left Bolster Truck Side Accel Z:+Z
13:Front Truck Right Bolser Car Side Accel Z:+Z
14:Front Truck Right Bolster Truck Side Accel Z:+Z
15:Front Truck Pivot Car Side Accel X:+X
16:Front Truck Pivot Car Side Accel Y:+Y
17:Front Truck Pivot Car Side Accel Z:+Z
18:Rear Truck LF Wheel Mnt Accel X:+X
19:Rear Truck LF Wheel Mnt Accel Y:+Y
20:Rear Truck LF Wheel Mnt Accel Z:+Z
21:Rear Truck RR Wheel Mnt Accel X:+X
22:Rear Truck RR Wheel Mnt Accel Y:+Y
23:Rear Truck RR Wheel Mnt Accel Z:+Z
24:Rear Truck Left Bolser Car Side Accel Z:+Z
25:Rear Truck Left Bolster Truck Side Accel Z:+Z
26:Rear Truck Right Bolster Car Side Accel Z:+Z
27:Rear Truck Right Bolster Truck Side Accel Z:+Z
28:Rear Truck Pivot Car Side Accel X:+X
29:Rear Truck Pivot Car Side Accel Y:+Y
30:Rear Truck Pivot Car Side Accel Z:+Z
31:Front Truck Long Link Load
32:Front Truck Short Link Load
33:Rear Truck Long Link Load
34:Rear Truck Short Link Load
RMS
1.07
1.88
0.88
0.87
1.71
0.83
0.06
0.41
0.07
0.41
0.24
0.32
0.09
0.91
1.68
0.69
0.99
1.7
0.83
0.06
0.4
0.06
0.4
0.21
0.48
0.08
98.45
649.04
213.27
524.39
Page. B3 of B4
Max
32.21
81.33
42.56
26.02
70.06
34.88
2.19
8.75
1.67
15.1
4.91
9.2
2.63
41.17
74.38
31.22
36
79.48
44.95
2.12
13.9
4.5
12.14
6.15
12.59
2.4
647.63
4004.28
625.82
3720.04
Min
-34.04
-74.01
-32.1
-37.68
-49.69
-29.62
-1.95
-10.54
-1.68
-12.21
-5.98
-7.26
-2.34
-44.5
-72.59
-43.37
-33.5
-75.68
-39.5
-1.5
-10.66
-1.31
-11.62
-6.76
-13.4
-2.02
-445.92
-4004.28
-513.72
-3574.18
Range
66.25
155.34
74.66
63.7
119.75
64.5
4.14
19.29
3.35
27.31
10.89
16.46
4.97
85.67
146.97
74.59
69.5
155.16
84.45
3.62
24.56
5.81
23.76
12.91
25.99
4.42
1093.55
8008.56
1139.54
7294.22
Average
-1.78E-06
-7.32E-07
8.68E-07
4.43E-07
1.13E-07
1.52E-09
1.87E-06
-1.12E-06
1.55E-06
-8.98E-07
-5.85E-07
1.88E-07
4.87E-07
-8.80E-07
3.45E-06
-1.12E-06
-8.48E-09
-1.77E-06
-1.52E-06
-2.76E-06
1.76E-06
1.01E-05
7.64E-06
1.37E-06
1.81E-06
-1.31E-06
71.42
443.13
178.94
389.59
EU
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
lbf
lbf
lbf
lbf
106145-000 Report
DEFIANCE
Statistics for Run4 Data
Channels
5:Front Truck LF Wheel Mnt Accel X:+X
6:Front Truck LF Wheel Mnt Accel Y:+Y
7:Front Truck LF Wheel Mnt Accel Z:+Z
8:Front Truck RR Wheel Mnt Accel X:+X
9:Front Truck RR Wheel Mnt Accel Y:+Y
10:Front Truck RR Wheel Mnt Accel Z:+Z
11:Front Truck Left Bolser Car Side Accel Z:+Z
12:Front Truck Left Bolster Truck Side Accel Z:+Z
13:Front Truck Right Bolser Car Side Accel Z:+Z
14:Front Truck Right Bolster Truck Side Accel Z:+Z
15:Front Truck Pivot Car Side Accel X:+X
16:Front Truck Pivot Car Side Accel Y:+Y
17:Front Truck Pivot Car Side Accel Z:+Z
18:Rear Truck LF Wheel Mnt Accel X:+X
19:Rear Truck LF Wheel Mnt Accel Y:+Y
20:Rear Truck LF Wheel Mnt Accel Z:+Z
21:Rear Truck RR Wheel Mnt Accel X:+X
22:Rear Truck RR Wheel Mnt Accel Y:+Y
23:Rear Truck RR Wheel Mnt Accel Z:+Z
24:Rear Truck Left Bolser Car Side Accel Z:+Z
25:Rear Truck Left Bolster Truck Side Accel Z:+Z
26:Rear Truck Right Bolster Car Side Accel Z:+Z
27:Rear Truck Right Bolster Truck Side Accel Z:+Z
28:Rear Truck Pivot Car Side Accel X:+X
29:Rear Truck Pivot Car Side Accel Y:+Y
30:Rear Truck Pivot Car Side Accel Z:+Z
31:Front Truck Long Link Load
32:Front Truck Short Link Load
33:Rear Truck Long Link Load
34:Rear Truck Short Link Load
RMS
1.12
2.23
0.96
0.91
1.75
0.85
0.06
0.43
0.07
0.4
0.24
0.33
0.09
0.92
1.71
0.7
0.98
1.72
0.85
0.06
0.4
0.06
0.4
0.22
0.49
0.08
177.82
638.79
135.14
576.17
Page. B4 of B4
Max
71.5
102.65
52.74
28.58
64.62
31.55
1.46
7.13
1.42
11.14
7.3
7.19
2.19
40.93
92.15
34.64
37.15
77.5
30.06
1.7
10.4
2.98
20.21
8.23
14.93
3.13
602.25
3877.65
850.09
3912.38
Min
-57.99
-66.74
-32.19
-31.66
-50.61
-21.51
-1.49
-7.76
-1.22
-9.28
-5.79
-6.75
-1.95
-35.27
-72.96
-22.1
-36.33
-73.41
-22.35
-1.84
-10.2
-1.47
-10.87
-7.03
-14.26
-2.26
-602.25
-3877.65
-445.26
-3795.06
Range
129.49
169.39
84.93
60.24
115.23
53.06
2.95
14.89
2.64
20.42
13.09
13.94
4.14
76.2
165.11
56.74
73.48
150.91
52.41
3.54
20.6
4.45
31.08
15.26
29.19
5.39
1204.5
7755.3
1295.35
7707.44
Average
-2.56E-06
-2.38E-05
-4.94E-07
1.10E-06
-1.75E-07
1.57E-07
1.95E-06
-2.37E-06
1.44E-06
-1.24E-06
-1.96E-06
-1.86E-06
1.81E-06
-1.36E-06
2.37E-06
-2.91E-06
1.71E-06
-6.28E-07
-3.72E-06
1.13E-06
-4.98E-07
5.42E-06
4.93E-06
1.05E-08
-1.72E-07
3.69E-07
148.02
504.34
105.07
384.04
EU
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
g
lbf
lbf
lbf
lbf
106145-000 Report
DEFIANCE
Appendix C
Result Plots
106145-000 Report
DEFIANCE
Link Load Time Plots with Max and Min Loads
4500.00
F
F
Curve
32:Front Truck Short Link Load Run1
31:Front Truck Long Link Load Run1
4000
1.00
Max
Min
4479.38 [email protected] s
-2974.81 [email protected] s
494.30 [email protected] s
-508.94 [email protected] s
3500
3000
2500
2000
1500
lbf
Real
Amplitude
1000
500
0
-500
-1000
-1500
-2000
-2500
880.00
-3000.00 0.00
0.00
0.00
3700.00
s
F
F
880.00
Curve
34:Rear Truck Short Link Load Run1
33:Rear Truck Long Link Load Run1
1.00
Max
Min
3631.59 [email protected] s
-3284.53 [email protected] s
1232.91 [email protected] s
89.84 [email protected] s
3000
2500
2000
1500
1000
lbf
Real
Amplitude
500
0
-500
-1000
-1500
-2000
-2500
-3000
880.00
-3300.00 0.00
0.00
0.00
s
Page. C1 of C16
880.00
106145-000 Report
DEFIANCE
3300.00
F
F
3000
Curve
32:Front Truck Short Link Load Run2
31:Front Truck Long Link Load Run2
1.00
Max
Min
3280.54 [email protected] s
-3817.44 [email protected] s
528.54 [email protected] s
-553.92 [email protected] s
2500
2000
1500
1000
500
lbf
Real
Amplitude
0
-500
-1000
-1500
-2000
-2500
-3000
-3500
-3900.00 0.00
0.00
0.00
3800.00
s
F
F
3500
870.00
Curve
34:Rear Truck Short Link Load Run2
33:Rear Truck Long Link Load Run2
1.00
Max
Min
3792.29 [email protected] s
-3790.12 [email protected] s
829.23 [email protected] s
-450.69 [email protected] s
3000
2500
2000
1500
1000
Amplitude
lbf
Real
500
0
-500
-1000
-1500
-2000
-2500
-3000
-3500
-3800.00 0.00
0.00
0.00
s
Page. C2 of C16
870.00
106145-000 Report
DEFIANCE
3700.00
F
F
Curve
32:Front Truck Short Link Load Run3
31:Front Truck Long Link Load Run3
1.00
Max
Min
3620.26 [email protected] s
-4004.28 [email protected] s
647.63 [email protected] s
-445.92 [email protected] s
3000
2500
2000
1500
1000
Amplitude
500
lbf
Real
0
-500
-1000
-1500
-2000
-2500
-3000
-3500
880.00
-4100.00 0.00
0.00
0.00
3800.00
s
F
F
3500
900.00
Curve
34:Rear Truck Short Link Load Run3
33:Rear Truck Long Link Load Run3
1.00
Max
Min
3720.04 [email protected] s
-3574.18 [email protected] s
625.82 [email protected] s
-513.72 [email protected] s
3000
2500
2000
1500
1000
Amplitude
lbf
Real
500
0
-500
-1000
-1500
-2000
-2500
-3000
880.00
-3600.00 0.00
0.00
0.00
s
Page. C3 of C16
900.00
106145-000 Report
DEFIANCE
3200.00
F
F
Curve
32:Front Truck Short Link Load Run4
31:Front Truck Long Link Load Run4
1.00
Max
Min
3176.41 [email protected] s
-3877.65 [email protected] s
593.67 [email protected] s
-602.25 [email protected] s
2500
2000
1500
1000
500
Amplitude
lbf
Real
0
-500
-1000
-1500
-2000
-2500
-3000
-3500
-3900.00 0.00
0.00
0.00
4000.00
s
F
F
870.00
Curve
34:Rear Truck Short Link Load Run4
33:Rear Truck Long Link Load Run4
3500
1.00
Max
Min
3912.38 [email protected] s
-3795.06 [email protected] s
850.09 [email protected] s
-445.26 [email protected] s
3000
2500
2000
1500
1000
Amplitude
lbf
Real
500
0
-500
-1000
-1500
-2000
-2500
-3000
-3500
-3800.00 0.00
0.00
0.00
s
Page. C4 of C16
870.00
106145-000 Report
DEFIANCE
Microphone Sound Pressure Levels Time Plots and RMS Sound Pressure Levels
Page. C5 of C16
106145-000 Report
DEFIANCE
Page. C6 of C16
106145-000 Report
DEFIANCE
Microphone Loudness Time Plots and RMS Loudness
Page. C7 of C16
106145-000 Report
DEFIANCE
Page. C8 of C16
106145-000 Report
DEFIANCE
rd
Microphone Sound Pressure Level 1/3 Octave Plots
Page. C9 of C16
106145-000 Report
DEFIANCE
Page. C10 of C16
106145-000 Report
DEFIANCE
Page. C11 of C16
106145-000 Report
DEFIANCE
Page. C12 of C16
106145-000 Report
DEFIANCE
Run1 Wheel Mount Acceleration Time Plots with Max/Min
80.00
Curve
70
F
F
F
F
F
F
60
5:Front Truck LF Wheel Mnt Accel X:+X
6:Front Truck LF Wheel Mnt Accel Y:+Y
7:Front Truck LF Wheel Mnt Accel Z:+Z
8:Front Truck RR Wheel Mnt Accel X:+X
9:Front Truck RR Wheel Mnt Accel Y:+Y
10:Front Truck RR Wheel Mnt Accel Z:+Z
Min
-33.46 [email protected] s
79.25 [email protected] s
50
1.00
Max
32.18 [email protected] s
-75.04 [email protected] s
41.57 [email protected] s
-31.12 [email protected] s
26.60 [email protected] s
-39.50 [email protected] s
68.19 [email protected] s
-51.09 [email protected] s
34.04 [email protected] s
-29.17 [email protected] s
40
30
20
Amplitude
g
Real
10
0
-10
-20
-30
-40
-50
-60
-70
879.21
-80.00 0.00
0.00
0.00
50
100
150
200
250
300
350
400
450
500
550
600
650
700
750
800
880.00
s
80.00
Curve
70
F
F
F
F
F
F
60
18:Rear
19:Rear
20:Rear
21:Rear
22:Rear
23:Rear
Truck LF Wheel Mnt Accel X:+X
Truck LF Wheel Mnt Accel Y:+Y
Truck LF Wheel Mnt Accel Z:+Z
Truck RR Wheel Mnt Accel X:+X
Truck RR Wheel Mnt Accel Y:+Y
Truck RR Wheel Mnt Accel Z:+Z
50
1.00
Max
Min
43.80 [email protected] s
-44.94 [email protected] s
77.07 [email protected] s
-73.22 [email protected] s
35.70 [email protected] s
-30.08 [email protected] s
35.75 [email protected] s
-33.67 [email protected] s
79.45 [email protected] s
-76.93 [email protected] s
45.68 [email protected] s
-32.34 [email protected] s
40
30
20
Amplitude
g
Real
10
0
-10
-20
-30
-40
-50
-60
-70
879.21
-80.00 0.00
0.00 50
0.00
100
150
200
250
300
350
400
450
500
550
600
650
700
750
800
880.00
s
Page. C13 of C16
106145-000 Report
DEFIANCE
Run2 Wheel Mount Acceleration Time Plots with Max/Min
110.00
Curve
100
F
F
F
F
F
F
90
80
5:Front Truck LF Wheel Mnt Accel X:+X
6:Front Truck LF Wheel Mnt Accel Y:+Y
7:Front Truck LF Wheel Mnt Accel Z:+Z
8:Front Truck RR Wheel Mnt Accel X:+X
9:Front Truck RR Wheel Mnt Accel Y:+Y
10:Front Truck RR Wheel Mnt Accel Z:+Z
Max
Min
1.00
70.10 [email protected] s
-55.72 [email protected] s
102.65 [email protected] s
-67.88 [email protected] s
47.77 [email protected] s
-31.90 [email protected] s
30.00 [email protected] s
-30.94 [email protected] s
65.78 [email protected] s
-50.72 [email protected] s
30.14 [email protected] s
-25.36 [email protected] s
70
60
50
40
Amplitude
g
Real
30
20
10
0
-10
-20
-30
-40
-50
-60
-70.00 0.00
0.00
0.00 50
100
150
200
250
300
350
400
450
500
550
600
650
700
750
800 870.00
s
100.00
Curve
90
F
F
F
F
F
F
80
70
18:Rear
19:Rear
20:Rear
21:Rear
22:Rear
23:Rear
Truck LF Wheel Mnt Accel X:+X
Truck LF Wheel Mnt Accel Y:+Y
Truck LF Wheel Mnt Accel Z:+Z
Truck RR Wheel Mnt Accel X:+X
Truck RR Wheel Mnt Accel Y:+Y
Truck RR Wheel Mnt Accel Z:+Z
1.00
Max
Min
41.13 [email protected] s
-34.72 [email protected] s
96.47 [email protected] s
-73.49 [email protected] s
36.92 [email protected] s
-29.36 [email protected] s
38.09 [email protected] s
-36.81 [email protected] s
76.27 [email protected] s
-75.80 [email protected] s
30.49 [email protected] s
-27.63 [email protected] s
60
50
40
30
Amplitude
g
Real
20
10
0
-10
-20
-30
-40
-50
-60
-70
-80.00 0.00
0.00 50
0.00
100
150
200
250
300
350
400
450
500
550
600
650
700
750
800 870.00
s
Page. C14 of C16
106145-000 Report
DEFIANCE
Run3 Wheel Mount Acceleration Time Plots with Max/Min
90.00
Curve
80
F
F
F
F
F
F
70
60
5:Front Truck LF Wheel Mnt Accel X:+X
6:Front Truck LF Wheel Mnt Accel Y:+Y
7:Front Truck LF Wheel Mnt Accel Z:+Z
8:Front Truck RR Wheel Mnt Accel X:+X
9:Front Truck RR Wheel Mnt Accel Y:+Y
10:Front Truck RR Wheel Mnt Accel Z:+Z
1.00
Max
Min
32.21 [email protected] s
-34.04 [email protected] s
81.33 [email protected] s
-74.01 [email protected] s
42.56 [email protected] s
-32.10 [email protected] s
26.02 [email protected] s
-37.68 [email protected] s
70.06 [email protected] s
-49.69 [email protected] s
34.88 [email protected] s
-29.62 [email protected] s
50
40
30
Amplitude
20
g
Real
10
0
-10
-20
-30
-40
-50
-60
-70
900.00
-80.00 0.00
0.00
0.00 50
100
150
200
250
300
350
400
450
500
550
600
650
700
750
800
900.00
s
80.00
Curve
F
F
F
F
F
F
70
60
18:Rear
19:Rear
20:Rear
21:Rear
22:Rear
23:Rear
Truck LF Wheel Mnt Accel X:+X
Truck LF Wheel Mnt Accel Y:+Y
Truck LF Wheel Mnt Accel Z:+Z
Truck RR Wheel Mnt Accel X:+X
Truck RR Wheel Mnt Accel Y:+Y
Truck RR Wheel Mnt Accel Z:+Z
50
1.00
Max
Min
41.17 [email protected] s
-44.50 [email protected] s
74.38 [email protected] s
-72.59 [email protected] s
31.22 [email protected] s
-43.37 [email protected] s
36.00 [email protected] s
-33.50 [email protected] s
79.48 [email protected] s
-75.68 [email protected] s
44.95 [email protected] s
-39.50 [email protected] s
40
30
20
Amplitude
g
Real
10
0
-10
-20
-30
-40
-50
-60
-70
900.00
-80.00 0.00
0.00 50
0.00
100
150
200
250
300
350
400
450
500
550
600
650
700
750
800
900.00
s
Page. C15 of C16
106145-000 Report
DEFIANCE
Run4 Wheel Mount Acceleration Time Plots with Max/Min
110.00
Curve
100
F
F
F
F
F
F
90
80
5:Front Truck LF Wheel Mnt Accel X:+X
6:Front Truck LF Wheel Mnt Accel Y:+Y
7:Front Truck LF Wheel Mnt Accel Z:+Z
8:Front Truck RR Wheel Mnt Accel X:+X
9:Front Truck RR Wheel Mnt Accel Y:+Y
10:Front Truck RR Wheel Mnt Accel Z:+Z
1.00
Max
Min
71.50 [email protected] s
-57.99 [email protected] s
102.65 [email protected] s
-66.74 [email protected] s
52.74 [email protected] s
-32.19 [email protected] s
28.58 [email protected] s
-31.66 [email protected] s
64.62 [email protected] s
-50.61 [email protected] s
31.55 [email protected] s
-21.51 [email protected] s
70
60
50
40
Amplitude
g
Real
30
20
10
0
-10
-20
-30
-40
-50
-60
-70.00 0.00
0.00
0.00 50
100
150
200
250
300
350
400
450
500
550
600
650
700
750
800 870.00
s
100.00
Curve
90
F
F
F
F
F
F
80
70
18:Rear
19:Rear
20:Rear
21:Rear
22:Rear
23:Rear
Truck LF Wheel Mnt Accel X:+X
Truck LF Wheel Mnt Accel Y:+Y
Truck LF Wheel Mnt Accel Z:+Z
Truck RR Wheel Mnt Accel X:+X
Truck RR Wheel Mnt Accel Y:+Y
Truck RR Wheel Mnt Accel Z:+Z
1.00
Max
Min
40.93 [email protected] s
-35.27 [email protected] s
92.15 [email protected] s
-72.96 [email protected] s
34.64 [email protected] s
-22.10 [email protected] s
37.15 [email protected] s
-36.33 [email protected] s
77.50 [email protected] s
-73.41 [email protected] s
30.06 [email protected] s
-22.35 [email protected] s
60
50
40
30
Amplitude
g
Real
20
10
0
-10
-20
-30
-40
-50
-60
-70
-80.00 0.00
0.00 50
0.00
100
150
200
250
300
350
400
450
500
550
600
650
700
750
800 870.00
s
Page. C16 of C16
106145-000 Report
DEFIANCE
Appendix D
Equipment List
Manufacturer/Model
B&K4166 Microphone
B&K4166 Microphone
PCB 356A15 Triaxial Accelerometer
PCB 356A15 Triaxial Accelerometer
PCB 356A15 Triaxial Accelerometer
PCB 356A15 Triaxial Accelerometer
PCB 356A15 Triaxial Accelerometer
PCB 356A15 Triaxial Accelerometer
PCB V352C67 Accelerometer
PCB V352C67 Accelerometer
PCB V352C67 Accelerometer
PCB V352C67 Accelerometer
PCB V352C67 Accelerometer
PCB V352C67 Accelerometer
PCB V352C67 Accelerometer
PCB V352C67 Accelerometer
LMS SCADAS MOBILE
LMS Test Lab 10A
SN / Asset
0013137
0038314
0039246
0041738
0041739
0039243
0039241
0041736
0039258
0039266
0039267
0039261
0039263
0039257
0039255
0039274
53092617
N/A
Page. D1 of D1
Calibration Due Date
4/9/2012
4/9/2012
8/1/2012
8/1/2012
8/1/2012
8/1/2012
8/1/2012
8/1/2012
10/12/2011
10/12/2011
10/12/2011
10/12/2011
10/12/2011
10/12/2011
10/12/2011
10/12/2011
N/A
N/A
106145-000 Report